Technotherm TT-KS 500 S Installation And Technical Manual - User Manual

Download PDF User Manual

Full Text Searchable PDF User Manual

TT-KS S

TT-KS N

TT-KS H

Installation and

technical manual

Electric Combination Heaters TT-KS mobile /castors

THESE INSTRUCTIONS SHOULD BE READ

CAREFULLY AND RETAINED FOR FUTURE

REFERENCE.

BE SURE TO OBSERVE ALL

LABELS AND WARNINGS ON THE APPLIANCE

Edition:12/17

Id_Nr. 911 360 950

Eco-Design Directive 2015/1188:

Feet using:

This product is only suitable for well-

insulated rooms or for occasional use

Manual TT-KS

1. For your safety

•

This appliance is intended for normal household

use and not for use for vehicles or on board

ships or aircrafts.

•

This appliance can be used by children aged

from 8 years and above and persons with

reduced physical, sensory or mental capabilities

or lack of experience and knowledge if they

have been given supervision or instruction

concerning use of the appliance in a safe way

and understand the hazards involved. Children

shall not play with the appliance. Cleaning and

user maintenance shall not be made by children

without supervision.

•

Children of less than 3 years should be kept

away unless continuously supervised.

•

Children aged from 3 years and less than 8

years shall only switch on/off the appliance

provided that it has been placed or installed in

its intended normal operating position and they

have been given supervision or instruction

concerning use of the appliance in a safe way

and understand the hazards involved. Children

aged from 3 years and less than 8 years shall

not plug in, regulate and clean the appliance or

perform user maintenance.

Manual TT-KS

•

CAUTION — Some parts of this product can

become very hot and cause burns. Particular

attention has to be given where children and

vulnerable people are present.

•

Make sure that your supply rating corresponds

to what specified on the rating plate: 230V~,

50Hz.

•

During function, place the heater in a safe

position:

- at least 1m far from inflammable objects or

furnitures;

- leaving not less than 1m of free space in

front of the heater;

- not located immediately below a socket-

outlet.

•

Do not leave animals or children touch or play

with the appliance.

•

Do not use the heater in rooms with explosive

gas or while using inflammable solvents or

varnish or glues.

•

If the cordset is damaged and you have to

change it, do not do the job yourselves! Take the

product to an after sales authorised repair centre

or to a person with similar skill and knowledge,

in order to avoid any risk of danger.

•

The appliance must be positioned so that the

plug is always accessible.

• Do not mount the product on walls made of

synthetic material.

Manual TT-KS

Electrical Connections:

The wires in the mains leads are colored in accordance with the following code:

GREEN & YELLOW:

EARTH

BLUE:

NEUTRAL

BROWN:

LIVE

WARNING – THIS APPLIANCE MUST BE EARTHED

The installation of this appliance should be carried out by a competent electrician in

accordance with I.E.E. Regulations for Electrical Equipment.

The radiator is fitted with a standard UK 3 pin plug or EURO plug that can be directly connected

to an

electrical socket. Care must be taken when connecting radiators in this way not

overload the ring main circuit. If you are unsure contact a qualified

electrician.

Alternatively the mains cable can be cut to length and connected to a suitable fused 20

amp

double-pole switched spur adjacent to the radiator. Please ensure that the

electricity supply is

disconnected prior to using this installation method.

Each supply circuit to the radiator must incorporate a Fused 20 Amp double pole

switched

spur having a contact separation of at least 3mm.

1.2 Handling

This radiator is very heavy. Take adequate precautions when lifting and maneuvering it.

Always

assess the load, and seek assistance with heavy or awkward loads that are

beyond your

capabilities.

1.3

Positioning

This radiator is very heavy. Please refer to Technical Data information contained within

this

document. In order to fulfil the ErP-Guideline, you need to use castors.

Wall mounting is not

allowed.

It is important that the following instructions are strictly followed.

Keep the following minimum safety distances to avoid fire risk due to high surface

temperatures of the appliance during heating cycles:

Lateral heating walls – masonry ................................................. 50 mm

Lateral heating walls – combustible matter ................................ 100 mm

Cover plate – combustible covering installed on top of it .......... 150 mm

Cover plate – non-combustible covering installed on top of it .. 100 mm

•

Please note that our IPX4 rated models should be used in bathrooms.

•

Portable radiators must not be fitted in bathrooms or wet areas.

•

CAUTION

– This radiator must not be located below or in front of

a fixed socket outlet.

•

DO NOT POSITION

under windows where curtains may contact the radiator.

•

DO NOT PLACE THE APPLIANCE

in the vicinity of a swimming pool.

Manual TT-KS

•

CAUTION

– If during any reassembly of the radiator, a part of the thermal insulation

shows damage or deterioration which may impair safety; it should be replaced with an

identical part.

•

CAUTION

– In order to avoid overheating, do not cover the radiator.

•

DO NOT COVER OR OBSTRUCT

the surfaces of the appliance.

•

DO NOT PLACE OBJECTS

in contact with the radiator

2.0

General Information

TECHNOTHERM Combination Electric radiators have been designed using the latest

technology to

create an elegant solution for all hard to heat situations. They can be installed in

almost

any location apart from the safety restrictions noted in this manual.

The range has been developed to provide a flexible solution for electric heating in

Domestic

properties, Conservatories, Holiday homes, Offices and any other temporary

heating situation.

Our unique patented ’Magmatic’ heating tablets provide the heat source for your new

radiator.

Whilst the radiator is classed as a 100% efficient Direct Acting appliance, the

heating tablets

provide partial storage to prolong your heating comfort and to reduce

running costs. The

radiator has a robust body which incorporates a spot welded high fin

surface area to ensure

that there are no contraction noises during the heating cycle.

The high fin design boasts 6

times the normal radiator surface area to provide a

balance of Convection and Radiant heat

for your added comfort.

The radiators can be simply plugged in to a “standard” socket or “hard” wired to an

existing

spur connection.

For added versatility we can supply Conservatory radiators which are also ideal for use

below

windows with low sills.

All our standard model sizes are supplied with

a E4

manual room thermostat. In addition to

the above we also supply Radio Frequency controlled radiators which provide all the

benefits of the standard version however the control wiring is eliminated. These

models can

controlled by our digital transmitter TBF or TPF.

All TECHNOTHERM radiators are manufactured to the highest safety and quality Standards.

Each

radiator is CE Marked and carries all the necessary European Approvals.

Each radiator is

fully checked and tested prior to leaving the factory and as such is packed

with full

Quality certification.

We hope you enjoy the comfort provided by this superior product and we look forward

being of assistance to you in the future.

Manual TT-KS

3.0 Preparation

Before beginning, remove the radiator

and parts from the box and check

everything is

present and correct

Model

Power

[Watt]

Dimensions

[cm]

Protection

class

TT-KS 500 S

500

38 x 63 x 7

IP 20

TT-KS 1000 S

1000

68 x 63 x 7

IP 20

TT-KS 1200 S

1200

68 x 63 x 7

IP 20

TT-KS 1500 S

1500

98 x 63 x 7

IP 20

TT-KS 1800 S

1800

98 x 63 x 7

IP 20

TT-KS 2000 S

2000

128 x 63 x 7

IP 20

TT-KS 2400 S

2400

128 x 63 x 7

IP 20

TT-KS 2800 S

2800

158 x 63 x 7

IP 20

TT-KS 700 S LT*

700

68 x 63 x 7

IP 20

ca.60°C ST

TT-KS 1200 S LT*

1200

98 x 63 x 7

IP 20

ca.60°C ST

TT-KS 1500 S LT*

1500

128 x 63 x 7

IP 20

ca.60°C ST

TT-KS 1800 S LT*

1800

158 x 63 x 7

IP 20

ca.60°C ST

TT-KS 500 S X4

500

38 x 63 x 7

IP 24

TT-KS 1000 S X4

1000

68 x 63 x 7

IP 24

TT-KS 1200 S X4

1200

68 x 63 x 7

IP 24

TT-KS 1500 S X4

1500

98 x 63 x 7

IP 24

TT-KS 800 N

800

68 x 34 x 7

IP 20

TT-KS 1200 N

1200

98 x 34 x 7

IP 20

TT-KS 1600 N

1600

128 x 34 x 7

IP 20

TT-KS 2000 N

2000

158 x 34 x 7

IP 20

TT-KS 800 N X4

800

68 x 34 x 7

IP 24

TT-KS 1200 N X4

1200

98 x 34 x 7

IP 24

TT-KS 1200 H

1200

38 x 124 x 7

IP 20

TT-KS 1800 H

1800

55 x 124 x 7

IP 20

TT-KS 2200 H

2200

68 x 124 x 7

IP 20

TT-KS 1200 H X4

1200

38 x 124 x 7

IP 24

HR 1200 KSB

1200

38 x 124 x 7

IP 24

HR 1200 deluxe

1200

52 (64) x 102 x 8,5 (14)

IP 24

ST = “surface temperature” - Surface temperature via the internal controller is set only by an electrical expert

The top grille of the radiator can then be

fitted and secured with the securing

screws at each

end.

At the bottom of the radiator, next to the

mains connection there is a small

temperature sensor.

Loosen the gland and

pull the sensor down by 50 - 70 millimeters,

then re-tighten the gland. This

enables the

radiator to gauge the room’s temperature

more accurately

3.2

Electrical connection

All TECHNOTHERM TT-KS radiators come with a

standard UK 3 pin plug that can be directly connected to

an electrical socket.

Alternatively the mains cable can be

cut to length and connected to a suitable

Fused 20 Amp

double-pole switched spur adjacent to the radiator.

Please ensure that the electricity supply is disconnected

prior to using this installation method. The mains plug

should be discarded safely and not re-used.

Manual TT-KS

3.3 Radio frequency – wired versions model E4

The regulation of the desired

room temperature implements a

built-in temperature control

device.

position 0 : OFF

position 1 : approx. 5°C (frost

protection)

position 4 : approx. 20°C

position 6 : approx 30°C

An illuminated display indicates

the heating process of the

radiator.

CAUTION

- After completion of works all electrical connections should be

tested for tightness.

Additionally an electrical safety check should be carried

out ie: short circuit, earth continuity,

resistance to earth and polarity check

and all the relevant test certificates produced.

3.4 Radio frequency – RF models

All Radio Frequency radiators come complete with a pre-wired TRF Receiver which is

controlled by the TPF Eco control.

TPF transmitter installation

Follow the instructions outlined on page 27 for single radiator installations according

to the instructions included in the TPF transmitter packaging.

Locate the TPF programmer on a suitable wall in the same room as the radiator.

CAUTION

– After completion of works all electrical connections should be

tested for tightness.

Additionally an electrical safety check should be carried

out ie: short circuit, earth continuity,

resistance to earth and polarity check

and all the relevant test certificates produced.

3.5 Installing castors and feet

All radiators are supplied with feet’s or castors however with the exception of

the Towel Rail.

Consult the leaflet which

comes with them for fixing instructions. The official feet or castors

must be used.

Manual TT-KS

4.0 Operating safety

This appliance complies with the European Standards EN 60 335-1, EN 60 335-2-61, EN

61000-3-2, EN 61000-3-3, EN 55014 and EN55104 for Safety & Electromagnetic

Compatibility. These standards cover the requirement of the EMC Directives 89/336 &

73/23

RADIATOR POSITIONING

- A minimum clearance of 150mm to the front of the

radiator is

essential for safety, however to enable the radiator to attain its maximum

performance ensure

that any furniture or other obstruction is not placed closer than

250mm.

THESE INSTRUCTIONS SHOULD BE READ CAREFULLY AND RETAINED FOR FUTURE

REFERENCE

CAUTION - THE SURFACE OF THIS RADIATOR CAN BE HOT.

The surface temperatures of this radiator are within the requirements of EN60-335 the

European Standard covering the safety requirements of electric heating appliances, and

momentary contact with any part of the radiator should not cause injury.

However, in order to be effective, radiators of any type do get hot, especially around

the air

outlet grille.

Therefore, if aged or infirm persons, or young children, are likely to be left

unsupervised in

the vicinity of a radiator precautions should be taken to ensure that

prolonged contact with

the radiator cannot occur. We recommend that a guard is fitted

around the radiator, as is

normal with some types of heating appliances in similar

circumstances.

CAUTION - IN ORDER TO AVOID OVERHEATING, DO NOT COVER THE SURFACES

THE RADIATOR AND DO NOT OBSTRUCT AIR OUTLET GRILLES

Surfaces of the

radiator should not be covered or obstructed as this can cause excessive

temperatures

that can be hazardous and may cause safety cut-outs to operate. For example,

do not

put clothes, fabrics or any combustible materials on the radiator or allow curtains to

come within 75mm (3”) of the top and ends of the radiator. Do not allow furniture to

be pushed

up against the radiator. A minimum clearance of 150mm is critical for safety,

however to

ensure radiator performance is not affected a clearance of 250mm is

recommended.

DO NOT PLACE OBJECTS IN CONTACT WITH THE RADIATOR

CAUTION

– The radiator must not be located below

or of in front of

a socket outlet.

PLEASE NOTE: THIS RADIATOR IS HEAVY

Manual TT-KS

No attempt should be made to move the radiator without first seeking

specialist advice. If you

are not happy that the radiator has been securely fixed, please

inform your installer.

DO NOT SIT OR STAND ON THE RADIATOR.

DO NOT SPILL LIQUIDS ONTO THE APPLIANCE. IF YOU DO, SWITCH THE RADIATOR

OFF AND GET A QUALIFIED ELECTRICIAN TO CHECK IT.

DO NOT POKE OBJECTS THROUGH THE GRILLE.

DO NOT USE POLISHES ON THE RADIATOR OR ON FURNITURE NEAR TO IT.

The hot

interior of the radiator can produce paraffin smells from polish vapors which may last

for a number of hours.

In case of breakdown or other failure, switch off the radiator at both wall

switches and

contact your supplier or the LHZ Help Desk on +49 (0) 3724 66869 0

Always

ensure that the radiator is switched off and fuse is removed before

any repair is carried out.

IMPORTANT

- Due to the newness of the materials the radiator will produce a slight

smell for

the first few days of operation.

ROOMS MUST BE WELL VENTILATED AND YOUNG CHILDREN, CAGED BIRDS OR

PERSONS WITH RESPIRATORY COMPLAINTS MUST NOT REMAIN IN CLOSE

PROXIMITY TO THE RADIATOR DURING THE FIRST 48 HOURS OF THE

COMMISSIONING PERIOD

Running the radiator at maximum temperature for the

first few days will help to dispel any smells

more quickly.

Please note that at high setting the room temperature will be warmer with a

corresponding

increase in running costs.

Safety - Overheat Protection

For your safety, this appliance is fitted with thermal cut-outs. In the event that the

product

overheats, the cut-outs switch the radiator off automatically. In the event of

these safety cut-

outs activating please inform the installer or the LHZ Help Desk.

Manual TT-KS

Cleaning

To maintain the external appearance of the radiator it need only be wiped over

occasionally

with a dry duster. During the summer months, or at other times when the

appliance is not is

use and is completely cold, the opportunity should be taken to wipe

over with a damp cloth.

Do not use abrasive cleaning powders or furniture polish.

Discoloration of wall finishes can

sometimes occur immediately above a radiator due to

the properties of some paints and

decorating materials or the presence of

environmental impurities in the air (such as soot or

incense generated from the burning

of candles etc.).

6. Regulation

From 01.01.2018, the EU conformity of these devices is additionally linked to the fulfillment of

the Ecodesign requirements 2015/1188.

The installation and commissioning of the devices is only permitted in conjunction with external

room temperature controllers that fulfill the following functions:

•

electronic room temperature control plus week timer

And has at least one of the following properties:

•

room temperature control, with presence detection

•

room temperature control, with open window detection

•

with distance control option

•

with adaptive start control

•

with working time limitation

•

with black bulb sensor

•

The following room temperature controller systems

•

RF Receiver together with the TPF-Eco Thermostat (Art.Nr.: 750 000 641) and the Eco-

Interface (Art.Nr.750 000 640) or

•

DSM-Thermostat with the DSM-Interface (Art.No.:911 950 101)

from Technotherm meet the following requirements and therefore the ErP Directive:

•

electronic room temperature control plus week timer (RF/DSM)

•

room temperature control, with open window detection (DSM)

•

with distance control option (DSM)

•

with adaptive start control (DSM)

Use of the TT-KS Standard range (without external thermostat control) is only permitted with castors

or on feet.

Installation of the receiver and the interfaces see separate instructions. For customer service - see last

page.

Failure to comply with these requirements will result in the loss of the CE mark.

Manual TT-KS

Model: TT-KS S DSM / TT-KS N DSM / TT-KS H DSM (additional DSM interface necessary)

Item

Symbol

Value

Item

Value

Heat output

Type of heat input, for electric storage local

space heaters only (select one)

Nominal heat

output

Pnom

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge control, with

integrated thermostat

Minimum heat

output

(indicative)

Pmin

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge control with

room and/or outdoor temperature

feedback

Maximum

continuous heat

output

Pmax,c

500

1000

1200

1500

1800

2000

2400

2800

Watt

electronic heat charge control with

room and/or outdoor
temperature feedback

Auxiliary

electricity

consumption

fan assisted heat output

At nominal heat

output

elmax

500

1000

1200

1500

1800

2000

2400

2800

Watt

Type of heat output/room temperature

control (select
one)

At minimum heat

output

elmin

<0,5

Watt

single stage heat output and no room

temperature control

In standby mode

elSB

<0,5

Watt

Two or more manual stages, no room

temperature control

with mechanic thermostat room

temperature control

with electronic room temperature

control

electronic room temperature control

plus day timer

electronic room temperature control

plus week timer

Yes

Other control options (multiple selections

possible)

room temperature control, with

presence detection

Nein

room temperature control, with open

window detection

Yes

with distance control option

Yes

with adaptive start control

Yes

with working time limitation

with black bulb sensor

Model: TT-KS S RF / TT-KS N RF / TT-KS H RF (additional TPF Thermostat and Eco-Interface necessary)

Item

Symbol

Value

Item

Value

Heat output

Type of heat input, for electric storage local

space heaters only (select one)

Nominal heat

output

Pnom

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge control, with

integrated thermostat

Minimum heat

output

(indicative)

Pmin

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge control with

room and/or outdoor temperature

feedback

Maximum

continuous heat

output

Pmax,c

500

1000

1200

1500

1800

2000

2400

2800

Watt

electronic heat charge control with

room and/or outdoor
temperature feedback

Auxiliary

electricity

consumption

fan assisted heat output

At nominal heat

output

elmax

500

1000

1200

1500

1800

2000

2400

2800

Watt

Type of heat output/room temperature

control (select
one)

At minimum heat

output

elmin

<0,5

Watt

single stage heat output and no room

temperature control

In standby mode

elSB

<0,5

Watt

Two or more manual stages, no room

temperature control

with mechanic thermostat room

temperature control

with electronic room temperature

control

electronic room temperature control

plus day timer

electronic room temperature control

plus week timer

Yes

Other control options (multiple selections

possible)

room temperature control, with

presence detection

Nein

room temperature control, with open

window detection

with distance control option

Yes

with adaptive start control

with working time limitation

nein

with black bulb sensor

nein

Contact details:

Lucht LHZ Elektroheizung GmbG & Co. KG | Reinhard-Schmidt.Str.1 D-09217 Burgstädt

Manual TT-KS

Lucht LHZ Elektroheizung GmbH & Co. KG

Reinhard-Schmidt-Str. 1

D-09217 Burgstädt

Fon: +49 (0) 3724 66869 0

Fax: +49 (0) 3724 66869 20

E-mail: info@technotherm.de

web:

www.technotherm.de

edition: 12/17

Model: TT-KS S E4 / TT-KS N E4 / TT-KS E4 (only additional with castors of feet´s)

Item

Symbol

Value

Item

Value

Heat output

Type of heat input, for electric

storage local space heaters only

(select one)

Nominal heat

output

Pnom

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge

control, with integrated

thermostat

Minimum heat

output

(indicative)

Pmin

500

1000

1200

1500

1800

2000

2400

2800

Watt

manual heat charge control

with room and/or outdoor

temperature feedback

Maximum

continuous heat

output

Pmax,c

500

1000

1200

1500

1800

2000

2400

2800

Watt

electronic heat charge

control with room and/or

outdoor
temperature feedback

Auxiliary

electricity

consumption

fan assisted heat output

At nominal heat

output

elmax

500

1000

1200

1500

1800

2000

2400

2800

Watt

Type of heat output/room

temperature control (select
one)

At minimum heat

output

elmin

<0,5

Watt

single stage heat output

and no room temperature

control

In standby mode

elSB

<0,5

Watt

Two or more manual

stages, no room

temperature control

with mechanic thermostat

room temperature control

with electronic room

temperature control

Yes

electronic room

temperature control plus

day timer

electronic room

temperature control plus

week timer

Other control options (multiple

selections possible)

room temperature control,

with presence detection

Nein

room temperature control,

with open window detection

with distance control option

with adaptive start control

with working time limitation

with black bulb sensor

TECTECHNOTHERM Service:

Fon: +49 (0)911-93 78 32 10

Ask a Question ?