Full Text Searchable PDF User Manual
Instruction Manual: VelectriX Urban 2.0
Page
1
CONTENTS
Safe Riding Recommendations
Page 2
Pre-Ride Checklist
Page 3
Display and Controls
Page 4
Maintenance
Page 8
Warranty
Page 9
Contact Details
Page 10
Service Log
Page 11
Model Specification
Page 12
Page
2
Safe Riding Recommendations
1.
Please ensure you are familiar with and follow all traffic laws
and regulations for your state. Please remember you may need
to review these when travelling interstate.
2.
Always wear a helmet when riding your bike.
3.
D
on’t lend your
bike to anyone who is unfamiliar with it.
4.
As with all bikes it is important that you stay within safe limits
and speeds. If you feel you are travelling too quickly for the
road conditions, then slow down!! High speeds will increase
risk of injury in the event of an accident.
5.
Please read and become familiar with
the “Pre
-
Ride Checklist”
in this manual before riding your bike.
6.
Switch the lights on your bike on when riding at all times of the
day or night.
If your bike doesn’t have lights fitted as standard,
it is recommended that you purchase them and fit before
riding.
7.
Your VelectriX bike must be returned to your servicing dealer
after 250kms or 6 weeks from date of purchase, whichever
comes first, to re-tension the spokes. Spokes should then be
re-tensioned every 1500kms.
Page
3
Pre-Ride Checklist
1.
Check your bike for any loose nuts, bolts or fixings.
2.
Check tyre pressures on your bike are correct. Please always
refer to the tyre manufactures suggested levels on the side of
the tyre. The following can be used as a guide only: Urban 2.0
(40-80psi).
3.
Check the tyres on your bike for any visible damage, wear and
tear or bald spots.
4.
Check that the brake levers have been installed correctly on
your bike. The left hand brake lever should operate the rear
brake and the right hand brake lever should operate the front
brakes.
5.
Check the brakes are working effectively to stop your bike and
the power from the motor halts when the brakes are on.
6.
Check that your bike is fitted with a working bell and reflectors.
7.
Check that the wheel nuts or quick release skewers on your bike
are tight.
8.
Check that the electronic functions on your bike are working.
9.
Check that the handlebars and stem are tightened.
10.
Check that all bags, baskets, boxes, etc. are securely fastened.
11.
Check that your battery has sufficient charge for your ride.
Page
4
LED Display and Controls
Your electric bike is equipped with a LED display, mounted on the left side
of the handlebar, and is controlled with the use of 2 buttons (MODE) and
(POWER)
Turning the Battery On/Off
To ride the bike with assisted power, you must first switch the battery on.
This is done by simply pressing the power button located on the top of the
battery. You will hear a short beep and the green lights will appear. To turn
off the battery, do the same and battery will beep and the lights will
disappear.
Page
5
Pedal With Assisted Power
With the battery now turned on, you can turn on the LED display, by
pushing and holding the red POWER button on the LED display for 2
seconds. The battery capacity red lights will appear on the top of the LED
display and the number 1 indicator light will turn red. You now have pedal
assisted power activated on the bike.
Selecting Pedal Assist Modes
There are 4 MODE settings on this bike, simply push the MODE button to
select a number between 1 and 4. The red LED lights will highlight which
MODE is selected. Level 1 is the lowest (slowest) level of power and level 4
is the highest (fastest). As you start to pedal, you will feel the motor engage.
To stop the motor engaging, simply stop pedalling or pull on the brake lever
to engage the brakes.
Automatic “
Power
Cut Off” Feature
This model is fitted with e-bike safety brake levers, which means that the
power to the motor will immediately disengage when either the left or right
hand side brake lever is used.
Walk Mode
With the power turned on, press and hold the MODE button and the bike
will be powered to 6kph walking speed. Simply release the button to stop,
this is a handy function for walking with the bike up steep inclines.
Page
6
Battery Instructions
Lock/Unlock Battery
This bike is supplied with a set of keys, which are needed to lock/unlock the
battery from the bike. The lock is located at the base of the battery on the
left hand side of the bike. Simply turn left or right to lock/unlock.
Removing The Battery From The Bike
To remove the battery, unlock the battery (make sure to remove the key
before removing battery), remove the seat post and slide the battery
vertically out from the bike. When reattaching the battery make sure to
lock the base to avoid unnecessary power failures or damage.
Page
7
Charging The Battery
You can charge the battery on or off the bike, but first make sure that the
battery is turned off (hold the button on top of the battery until you hear a
short beep and the LED lights disappear). Now plug the battery charger
(supplied with this bike) into the charging port, which is positioned towards
the top of the battery on the right side. Once connected to the battery the
charger can then be turned on at the power socket. A GREEN light will
indicate when the battery is fully charged. Max charge time is 4 hours.
The Battery Charger
ONLY use the battery charger supplied with this bike.
Page
8
Maintenance
1.
Your VelectriX bike should be returned to your servicing dealer
for servicing and a thorough inspection once every 9 months or
1500kms, whichever comes first. Excluding the electronics,
motor, battery and wiring, your VelectriX bike is a normal bike,
with normal components. Your dealer will be able to explain to
you the general care and maintenance required for the
components of your bike.
2.
Once a month lubricate all pivot points on your derailleur and
derailleur pulleys with suitable chain lube.
3.
You can clean your bike with warm soapy water, however,
please do not submerge any electrical components or use a
high pressure hose. You can wipe dry the bike with a cloth.
Page
9
Warranty
All VelectriX bikes are covered by the following warranty and conditions
of use:
Battery
2 years
Motor
2 years
Frame
5 years
Other Components
1 year (excluding consumables: cables, tyres,
tubes, hand grips).
The warranty is only valid for the first owner and is not
transferrable.
The warranty commences from the date of purchase and proof of
purchase must be provided to cover any warranty parts.
All commercial use is excluded.
All Accidental damage is excluded.
All damage caused from misuse is excluded.
All repairs must be completed by a VelectriX dealer.
The bike must be serviced every 1500kms or every 9 months,
whichever the sooner.
Page
10
Contact Details
If you have any questions, concerns or technical issues with any VelectriX
product please contact your VelectriX dealer immediately.
Dealer Name:
Dealer
Contact Number
Address
Sales Person
Sales Date
VelectriX Australian Service Centre Contact Details:
VelectriX Pty Ltd
Phone:
1300 530 031
Visit:
10 Capital Place, Birtinya, Qld, 4575
Website:
www.velectrix.com.au
Email:
store@velectrix.com.au
Page
11
Service Log
Date
Km
Notes
Next Service Due
Date: / / OR Km
Date
Km
Notes
Next Service Due
Date: / / OR Km
Date
Km
Notes
Next Service Due
Date: / / OR Km
Date
Km
Notes
Next Service Due
Date: / / OR Km
Date
Km
Notes
Next Service Due
Date: / / OR Km
Page
12
Model Specification
VelectriX Urban Mens 2.0
Frame:
Aluminium VelectriX Urban Mens
Size:
50cm
Fork:
Aluminium fixed front fork
Colour:
Satin black
Tyres:
Kenda K Shield 700c x 38c
Brakes:
Shimano mechanical discs/Tektro levers
Gears:
Shimano Acera 7 speed
Motor
:
36 volt 250 watt rear hub motor
Battery:
36 volt Panasonic 11.6ah lithium ion
Battery Charger:
Kushan ST Electronics Li-Ion STC-8108L. 3a 240V
Maximum Speed
:
25 km/h
Weight
:
20.5kgs (inc. battery)
Range
:
Up to 60kms (MODE 1)
Carrying Capacity
:
110kgs (including battery, rider & accessories)
Page
13
Model Specification
VelectriX Urban Unisex 2.0
Frame:
Aluminium VelectriX Urban Unisex
Size:
46cm
Fork:
Aluminium fixed front fork
Colour:
Anthracite grey
Tyres:
Kenda K Shield 700c x 38c
Brakes:
Shimano mechanical discs/Tektro levers
Gears:
Shimano Acera 7 speed
Motor
:
36 volt 250 watt rear hub motor
Battery:
36 volt Panasonic 11.6ah lithium ion
Battery Charger:
Kushan ST Electronics Li-Ion STC-8108L. 3a 240V
Maximum Speed
:
25 km/h
Weight
:
20.5kgs (inc. battery)
Range
:
Up to 60kms (MODE 1)
Carrying Capacity
:
110kgs (including battery, rider & accessories)